Product ID:SG-50 (A,B)
MSDS Date:02/19/1992
FSC:8030
NIIN:01-127-3683
MSDS Number: BQDPR

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 414-233-7146

Preparer: MIKE SCHARPF

Cage: 0NLJ2

Telephone: 414-233-7146

Cage: 0NLJ2

HYDROTREATED LIGHT PETROLEUM DISTILLATE (MINERAL SPIRITS)

CAS: 64742-47-8

RTECS: GA5504000

Fraction By Weight: 46%

OSHA PEL 400 PPM/1600 MG/M3

ACGIH TLV: 100 PPM/525 MG/M3 *

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE TOXICOLOGICAL PROPERTIES; FOR
MINERAL SPIRITS: INHALATION - IRRITATION OF EYES, NOSE, THROAT,
DIZZINESS. SKIN CONTACT - DERMATITIS. EYE CONTACT - IRRITATION.
INGESTION - NAUSEA, VOMITING. LARGE AMOUNTS, IF RETAINED, LEAD TO
SYMPTOMS OF CENTRAL NERVOUS SYSTEM DEPRESSION.
Effects of Overexposure:CHRONIC EFFECTS OF OVEREXPOSURE: MAY CAUSE EYE,
NOSE AND THROAT IRRITATION AND DIZZINESS IF USED IN UNVENTILATED
AREA.

First Aid:EYES: FLUSH W/WATER 15 MIN. IF IRRIT PERSISTS, CONTACT DR.
SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN W/SOAP & WATER. IF
IRRITATION DEVELOPS, CONTACT DR. INHALATION: REMOVE TO FRESH AIR.
IF NOT BRE ATHING GIVE ARTIF RESPIRATION, PREFERABLE MOUTH TO
MOUTH. IF BREATHING DIFFICULT, GIVE OXYGEN. CALL DR IMMED.
INGESTION: DONT INDUCE VOMITING. CONTACT DR IMMEDIATELY. NOTHING BY
MOUTH TO UNCONSCIOUS.

Flash Point Method:PMCC
Flash Point:106F,41C
Lower Limits:.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, CLOSED CONTAINERS EXPOSED
TO FIRE MAY BE COOLED WITH WATER SPRAY.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS IS
RECOMMENDED FOR FIREFIGHTERS. WATER SPRAY MAY BE USED WITH CAUTION
TO PREVENT SPREAD OF FLAMES.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:STOP LEAK & DIKE LRG SPILL. AVOID IGNITION
SOURCES SUCH AS FLAME & SPARK. VENT. TRANSFER TO CNTNR FOR
DISPOSAL/RECYCLE. SEAL CNTNR. ABSORB REMAINING SPILL/LEAK
W/SAND,EARTH,VERMIC. SWEEP UP, DISPOSE O F ACCORDING TO FEDERAL,
STATE & LOCAL REGULATIONS.

Handling and Storage Precautions:COMBUSTIBLE-KEEP FROM HEAT/IGNIT
SOURCES. WEAR PROTECT CLOTHING/EQUIP WHEN HANDLING. KEEP CNTNRS
SEALED UNTIL USE. AVOID EXCESSIVE STORAGE TEMPS(>52C)
Other Precautions:DONT STORE NEAR STRONG OXIDIZERS. AVOID CONTACT
W/SKIN, EYES, CLOTHING. WASH CLOTHING BEFORE REUSE. DONT USE
PRESSURE TO EMPTY CONTAINER. WHEN EMPTY, CONTAINER MAY RETAIN PROD
RESIDUE. DONT CUT, PUNCT URE OR WELD ON/NEAR DRUM.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH DUAL
ORGANIC VAPOR/MIST AND PARTICULATES CARTRIDGE IF VAPOR
CONCENTRATION EXCEEDS PERMISSIBLE EXPOSURE LIMIT.
Protective Gloves:RUBBER OR PLASTIC, SOLVENT RESISTANT
Eye Protection:CHEMICAL SAFETY GOGGLES/FULL FACE SHIELD
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<2 @ 20 C
Vapor Density:>1
Spec Gravity:.924
Viscosity:>/= 100 @100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN, BLACK, GRAY THIXOTROPIC LIQUID (OPAQUE);
SLIGHT KEROSENE-LIKE ODOR.
Percent Volatiles by Volume:46

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS HYDROGEN PEROXIDE, BROMINE AND CHROMIC ACID.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
FROM BURNING. OXIDES OF SULFUR.

Waste Disposal Methods:DIPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.